GEOTHERMAL DOMESTIC HW & HYDRONIC
Not Your Device? Search For Manuals or Datasheets below:
File Info : application/pdf, 4 Pages, 674.76KB
Document DEVICE REPORTAG1006TWGEOTHERMAL DOMESTIC HW & HYDRONIC STORAGE TANKS ENERGY EFFICIENT WaterFurnace geothermal storage tanks, available in 80 or 119 gallon capacities, are specifically designed to provide consistent water temperature and constant hot water in geothermal systems! Large plumbing connections, 2 in. (R-16) insulation, built-in temperature sensor, and chilled water approved make these tanks the perfect choice for geothermal hydronic systems. Complete with extra plumbing connections and deluxe features, our storage tanks are also a great choice for geothermal domestic hot water systems. Application FlexibilitHyOT 3/4 in. Domestic HOT 3/4 in. Domestic DOMESTIC HOT HOT COLD 3/4 in. Domestic 1 in. Connections COLD 3/4 in. Domestic 1 in. Connections domestic hot water A pair of 1 in. connections on top of the storage tanks allow for easy installation and troublefree operation in geothermal hot water assist systems. DOMESTIC 1-1/2 in. FPT 1-1/2 in. FPT NOTE: Geo Storage Tank only will not provide 100% domestic hot water and is recommended to connect a water heater in series as shown in the diagram. Domestic WaterFurnace Hot Water Heater Geo Storage Tank Domestic WaterFurnace Hot Water Heater Geo Storage Tank WaterFurnace ENVISION WaterFurnace ENVISION HOT COLD HOT COLD Geothermal hydronic Large 1-1/2 in. FPT re-circulating side connections (shipped plugged) are included for high-flow water-to-water units. The upper element provides easy use of auxillary/backup heat. The lower access panel houses a factoryinstalled thermistor for accurate tank set-point control. HYDRONIC HYDRONIC 1-1/2 in. FPT 1-1/2 in. FPT TO NSW TO NSW FROM NSW *NOTE: A 30 PSI pressure relief valve (Part No: SRV30) shouFldRObeMuNseSdWin hydronic applications. *NOTE: A 30 PSI pressure relief valve (Part No: SRV30) should be used in hydronic applications. TO DSH TO DSH FROM DSH FROM DSH HOT HOT DOMESTIC DOMESTIC HOT COLD HOT COLD WaterFurnace NSW Series WaterFurnace NSW Series Domestic WaterFurnace Hot Water Heater Geo Storage Tank Domestic WaterFurnace Hot Water Heater Geo Storage Tank Other Application Features All `cold' connections feature a diffuser dip tube to reduce lime and sediment buildup and maximize equipment efficiency. Made from PEXAN, a cross linked polymer, these connections can withstand long term exposure to temperatures up to 400°F. Factory installed temperature/pressure relief valve. UL 174 Certified for household electric water heaters and factory approved for chilled water storage. Reliability Glass-lined tank with two anode rods. Primary and secondary aluminum anode rods provide maximum protection against corrosion. Brass tamper-resistant drain valve provides durability and longer life than plastic valves. Sandhog low Watt density 4500 Watt Incoloy Steel Heating Element is designed to last 2 to 3 times longer than standard copper heating elements. 6-Year Limited Tank and Parts Warranty. From Geo 1 x 3 Nipple PRIMARY ANODE 39 - 80 Gallon 42 - 119 Gallon 3/4 HOT OUTLET w/14 SECONDARY ANODE Approx. 1 T & P VALVE HEIGHT Optional "To Geo" Connection Shipped with 1-1/2 Pipe Plug Installed 30° 30° To Geo 59 Dip Tube w/1 x 3 Nipple 8 3/4 COLD INLET 52 DIP TUBE Yellow Wire attached to Thermistor or Thermostat for Top Exit Element Location 35-3/4 DRAIN VALVE DIAMETER Lower Sensor Thermistor (12P541-01) to be used by Water to Water Units Optional "From Geo" Connection Shipped with 1-1/2 Pipe Plug Installed 5-1/4 Lower Thermostat to be used with Synergy units MODEL NUMBER GALLON CAPACITY GEO-STORAGE-80 80 GEO-STORAGE-120 119 ELEMENT WATTAGE (240 VOLT) 4500 4500 RECOVERY 90°F RISE GALLONS/HR 21 21 NUMBER OF ELEMENTS 1 1 R VALUE 16 16 DIMENSIONS IN INCHES HEIGHT DIAMETER 63-1/4 24 63-1/4 28 APPROX. SHIPPING WEIGHT (lbs.) 204 311 PLUMBING DIAGRAMS GEO STORAGE TANK Dielectric Unions 1-1/2 in. FPT Ball Valve Source IN P/T Ports P/T Ports Source OUT WaterFurnace NSW018H or 025H P/T Ports 30 PSI RELIEF VALVE Pressure Gauge Air Vent LOAD PUMP Back Flow Preventer / Pressure Relief Valve Dielectric Unions Expansion Tank Air Separator Ball Valve GEO STORAGE TANK HYDRONIC LOAD 1-1/2 FPT *NOTE: A 30 PSI pressure relief valve (Part No: SRV30) should be used in hydronic applications. Dielectric Unions WaterFurnace Synergy3D 30 PSI RELIEF VALVE Pressure Gauge Air Vent LOAD PUMP Back Flow Preventer / Pressure Relief Valve Dielectric Unions Expansion Tank Air Separator Ball Valve HYDRONIC LOAD GEO STORAGE TANK TO DSH FROM DSH 1-1/2 in. FPT Dielectric Unions P/T Ports Source IN P/T Ports *NOTE: A 30 PSI pressure relief valve (Part No: SRV30) should be used in hydronic applications. Source OUT WaterFurnace NSW Series Pump & pipe guide Unit Cu Pipe Flow Rates PD w/30' Grundfos Model Size (in) (gpm) pipe (ft hd) Pump Model NSW018 1.0 5 NSW025 1.25 7 NSW040 1.25 10 NSW050 1.5 15 NSW060 1.5 18 NSW070 1.5 19 SDV038 1.25 9 SDV049 1.25 12 SDV064 1.25 15 SDV072 1.5 18 Note: * Internal pump 4.5 UP26-99 8.2 UP26-99 8.9 UP26-99 13.6 UP26-99 16.6 UP26-99 18.7 UP26-99 * UP26-99* * UP26-99* * UP26-99* * UP26-99* PARTS Description Top Element 4500 Watt/240V 5500 Watt/240V 6000 Watt/240V Lower Bung with 1/8 tapped sensor 1 in. NPSM with 1/8 in. FPT for sensor Single Element Thermostat Part Number 19P579-03 19P579-02 19P579-01 22P554-01 19P582-01 NOTE: All Geo Storage tank replacement parts are drop shipped and do not include freight. type l copper pressure loss Ft of Hd per 100 ft Type L Copper Tube GPM 3/4 1 1-1/4 1-1/2 2 2 1.5 3 3.2 4 5.5 1.4 5 8.5 2.1 6 2.9 1.1 7 3.9 1.4 8 5.0 1.8 9 6.1 2.3 0.9 10 7.5 2.8 1.1 12 3.9 1.6 14 5.2 2.1 16 6.6 2.7 18 8.2 3.4 20 10.0 4.1 1.1 22 5.0 1.3 25 6.3 1.6 30 2.2 35 2.9 40 3.8 45 4.7 50 5.7 Note: Standard piping practice limits pressure drop to 4 ft of hd per 100 ft. AG1006TW 04/10 ©2010 WaterFurnace International, Inc., 9000 Conservation Way, Fort Wayne, IN 46809-9794. WaterFurnace has a policy of continual product research and development and reserves the right to change design and specifications without notice.Adobe PDF Library 8.0 Adobe InDesign CS3 (5.0.4)