AVANTCO 447AP23R Commercial Refrigerators And Freezers User Manual

User Manual

Commercial Refrigerators And Freezers Refrigerator models: 447AP23R, 447AP49R 10/2021 Freezer models: 447AP23F, 447AP49F Please read the manual thoroughly prior to equipment set-up, the operation, and maintenance.

Warning

DANGER – RISK OF FIRE OR EXPLOSION. FLAMMABLE REFRIGERANT USED. TO BE REPAIRED ONLY BY TRAINED SERVICE PERSONNEL. DO NOT PUNCTURE REFRIGERANT TUBING. CAUTION – RISK OF FIRE OR EXPLOSION. FLAMMABLE REFRIGERANT USED. CONSULT THE REPAIR MANUAL/OWNER’S GUIDE BEFORE ATTEMPTING TO SERVICE THIS PRODUCT. ALL SAFETY PRECAUTIONS MUST BE FOLLOWED. CAUTION – RISK OF FIRE OR EXPLOSION DUE TO PUNCTURE OF REFRIGERANT TUBING; FOLLOW HANDLING INSTRUCTIONS CAREFULLY. FLAMMABLE REFRIGERANT USED. CAUTION – RISK OF FIRE OR EXPLOSION DUE TO FLAMMABLE REFRIGERANT USED. FOLLOW HANDLING INSTRUCTIONS CAREFULLY IN COMPLIANCE WITH LOCAL GOVERNMENT REGULATIONS.

Installation

Please read this manual thoroughly prior to equipment set-up, operation, and maintenance. Important!!! Please Read Before Installation

• If the shelf has a raised lip, the lip needs to be installed facing up towards the rear of the cabinet to promote proper airflow. Failure to install the shelves properly is considered a user error and is not covered by a warranty.
• If the unit has recently been transported on its side, please let the unit stand upright for a minimum of 24 hours before plugging it in.
• Make sure the unit has reached the desired temperature before loading the unit with products.
• Make sure all accessories are installed (shelves, shelf clips, etc…) before plugging in the unit.
• Do not attempt to remove or repair any component of the unit. Consult an authorized service technician for servicing/repair.
• Do not hang on doors or stand inside the unit.
• Please read through this manual in its entirety.

• Install the unit on a strong and leveled surface. - If the surface is uneven, the unit may be noisy. - The unit may malfunction if the surface is uneven.
• Install the unit in an indoor, well-ventilated area. - For best performance, maintain 6” of clearance on both sides and the back of the unit at all times. - Outdoor use may cause decreased efficiency and damage to the unit. - Avoid direct sunlight.
• Avoid installation in high humidity and/or dusty area. - High humidity can cause the unit to rust and may decrease efficiency. - Dust collected on the condenser coil may cause the unit to malfunction. - Malfunction due to high ambient temperatures, humidity, or improperly maintained condenser coil will void the warranty.
• Select a location away from heat and moisture-generating equipment. - High ambient temperatures may cause the compressor to malfunction. - Malfunction due to high ambient temperatures and humidity will void the warranty.

• Cut the four straps which attach the unit to the pallet.
• Adjust the unit on the pallet until the pre-drilled holes are exposed.
• Using wedges or team-lift, lift the unit high enough that there is enough clearance to affix the caster.

CAUTION! NEVER LAY UNIT ON ITS BACK! THE UNIT SHOULD ONLY BE PLUGGED IN WHEN IT HAS RESTED IN THE CORRECT UPRIGHT POSITION FOR AT LEAST 24 HOURS. Failure to meet this requirement will void warranty coverage if compressor damage ensues.

• For leveling, if dealing with a sloped or uneven floor, shims are provided. Insert any necessary shims between the caster and the frame rail. Make sure the slot of the shim is in contact with the treaded stem of the caster. If using more than one shim, it is necessary to place them in opposite directions. If multiple shims are placed side by side in the same direction, they may dislodge.
• Turn the bearing race clockwise to tighten and secure the caster. Use provided a tool to secure all casters properly.

Field Convertible Doors The Avantco AP-23R and AP-23F models ship with a right-hinged door design. These single door models have the ability to be switched to a left-hinged door design. Please follow the instructions below:

• Phillips Head Screwdriver
• 10mm Wrench

1. Use the Phillips head screwdriver to remove the front panel screws, followed by the front panel.
2. Use the wrench to remove the bottom hinge hex screw, then loosen the hinge screws and carefully remove the door.
3. Use the screwdriver to remove the bottom and top hinges.
4. Use the wrench to remove the bolt of the top hinge, then install the bolt into the bottom hinge.
5. Install the bottom right hinge on the top left side of the equipment. Then, install the top right hinge on the bottom left side of the equipment.
6. Remove the bottom cartridge and bolt housing from the door, and install the cartridge at the top of the door and the bolt housing at the bottom.
7. Remove the top head screws, then move the hinge cap to the right side. Reinstall the top head screws.
8. Install the hinges on the left side, but do not tighten the screws. Then, install the door and cartridge screw. Tighten all screws.
9. Reinstall the front panel with the hinge cap on the right side.

Electrical

• Please ensure that the required voltage is supplied at all times.
• The unit should be plugged into a grounded and properly-sized electrical outlet with appropriate over-current protection. Please refer to the electrical requirements on the unit’s nameplate.
• The unit should have its own dedicated outlet.
• Do not use extension cords.
• Ensure the unit is not resting on or against the electrical cord.
• If the unit is not in use for a long period of time, please unplug the unit from the outlet.
• To avoid shock and fire hazards, do not plug in or unplug the unit with wet hands.
• After unplugging the unit, wait at least 10 minutes before plugging it back in. Failure to do so could cause damage to the compressor.

Adjusting the Temperature

Your new refrigerator or freezer is already factory-set to run at optimum temperatures for food safety and should require no adjustments. Refrigerators are set to cycle between a minimum temperature of 32°F and a maximum temperature of 38°F. Freezers are set to cycle between a minimum temperature of -8°F and a maximum temperature of 0°F. Adjusting the temperature changes the minimum temperature your unit will run at. Your unit will not run constantly at this setting. To change it, follow these instructions:

• Hold “SET” for 1 sec. The display will flash the current minimum temperature.
• Use the arrow buttons to adjust the minimum temperature you want it to run at.
• Press “SET” again to save your settings

Always remember to calculate the differential if you change the minimum temperature setting. The cabinet temperature will fluctuate up to +6°F for refrigerators and +8°F for freezers over your set minimum temperature as the compressor runs and shuts off. Setting the temperature too high will result in unsafe maximum temperatures and possible health code violations.

ECO Mode Your new APlus Reach-in Refrigerator or Freezer is equipped with Eco Mode which will cut down on energy costs and support the longevity of your unit. When the unit automatically detects a time of no use, it will switch into a power-saving mode: Eco Mode. After two hours of no door openings, your unit will automatically select a more efficient food-safe temperature to maintain for four hours. The compressor will work less during the downtime of your kitchen. You can also enable Eco Mode manually at any time you choose via the electronic controller. Eco Mode will stop when the door opens or when it is toggled off on the controller.

Instructions:

Automatic Mode:

• Your unit’s setting is to automatically detect times to implement eco mode.
• When your unit detects no door openings for two consecutive hours, the temperature setting the point will be slightly higher, allowing the compressor to run less
• Eco Mode will run for four consecutive hours or until the door is opened for more than 6 seconds, when it will toggle off

• Press the “ECO” button on the controller.
• The screen will display “ECO”
• The temperature will be set to a slightly higher maintenance temperature, allowing the compressor to run less
• If you wish to end Eco Mode, press the “ECO” button again
• Alternatively, Eco Mode will automatically end when the unit’s door is opened for more than 6 seconds or after four hours of being in Eco Mode

Running a Manual Defrost Cycle This unit is pre-programmed to run automatic defrost cycles at preset intervals. However, if you would like to run a manual defrost cycle at any time, please follow the steps below: Refrigerators: Press the defrost button (down arrow) for approximately 3 seconds. Repeat to stop the defrost cycle. Freezers: Press the defrost button (down arrow) for approximately 5 seconds. Repeat to stop the defrost cycle.

Defrost System Refrigerator coils are kept below the freezing point (32 degrees Fahrenheit). During compressor downtime, the evaporator fan continues to circulate air through the evaporator coil. This air circulation raises the coil temperature above the freezing point, melting any accumulated frost. Run-off water is drained into the evaporator pan and evaporated. Freezer coils are defrosted electrically. Automatic defrost timers automatically initiate at pre-set intervals and for a pre-determined duration.

Operation/Maintenance

NOTE: We strongly recommend that any servicing be performed by an authorized service technician. Loading Product

• Do not block the air duct/fan at the top of the unit. Maintain a minimum of 4” of clearance between products and the fan at all times.
• Ensure all shelves are sitting level and properly secured before loading products.
• Do not store flammable and explosive gas or liquids inside the unit.

• For efficient operation, keep the condenser surface free of dust, dirt, and lint.
• We recommend cleaning the condenser coil at least once per month.
• Clean the condenser with a commercial condenser coil cleaner, available from any kitchen equipment retailer.

• If necessary, clean the fan blades and motor with a soft cloth.
• If it is necessary to wash the fan blades, cover the fan motor to prevent moisture damage.

• When cleaning the cabinet interior, use a solvent of warm water and mild soap.
• Do not use steel wool, caustic soap, abrasive cleaners, or bleach that may damage the interior finish.
• Wash door gaskets on a regular basis, preferably weekly. Simply remove the door gasket from the frame of the door, soak it in warm water and soap for thirty (30) minutes, then dry with a soft cloth and replace it.
• Check door gaskets for proper seals after they are replaced.
• Periodically remove the shelves and shelf brackets from the unit, and clean them with mild soap and warm water.

Trouble Shooting

The compressor is Not Running

Documents / Resources

AVANTCO 447AP23R Commercial Refrigerators And Freezers [pdf] User Manual 447AP23R, 447AP49R, 447AP23F, Commercial Refrigerators And Freezers

Documents - avantco – 447AP23F,447AP23R,447AP49R

	[pdf] Avantco Refrigeration Controller Kits Compatibility Chart 16 янв 2025 г — 447AP23F 1 Door Reach In Freezer 44712040693 447AP49F 2 447AP23R Refrigerator controller kits compatibility chart srsltid AfmBOoqJOSY6OQ67CmGo6LZ3I NNjpnGlRh 2XmAp4gOdPun5ww LOM webstaurantstore documents ||| Controller Kits Compatibility Chart SERIAL #: 8103301704 BELOW Model 447AP23F 447AP49F 447AP23R 447AP49R Description Avantco 1 Door Reach-In Freezer Avantco 2 Door Reach-In Freezer Avantco 1 Door Reach-In Refrigerator Avantco 2 Door Reach-In Refrigerator Controller # 44712040693 44712067649 S... lang:it score:67 filesize: 39.22 K page_count: 1 document date: 2025-01-09
	[pdf] Guide Warranty Avantco Reach In Refrigeration Buying Guide reachin refrigerationguide webstaurantstore documents buying guide ||| Buying Guide 06/2023 Aluminum Interior Reach-In Refrigeration High-Performance R290 Hydrocarbon Re ... ITY 80 lb. 80 lb. CAPACITY 20 cu. ft. 43 cu. ft. HP 1/4 HP 1/3 HP A-Plus Series Freezers ITEM # 447AP23F 447AP49F WIDTH DEPTH HEIGHT DOORS 275/8 311/4 80 1 DOOR TYPE Solid HANDLES Full Len... lang:en score:55 filesize: 1.41 M page_count: 2 document date: 2023-06-14
	[pdf] User Manual Guide User Manual< b> WebstaurantStore manual< owner’s guide before attempting to service this product all safety precautions must be followed atencion riesgo de incendio o explosiÓn refrigerante inflamable utilizado consulte el reparaciÓn guÍa del propietario antes intentar dar servicio a este producto deben cumplir con todas las precauciones seguridad aplus_reach_in_manual cdnimg webstaurantstore documents pdf Manual manual User Manual Commercial Refrigerators And Freezers Refrigerator models: 447AP23R, 447AP49R Freezer models: 447AP23F, 447AP49F 05/2021 Please read the manual thoroughly prior to equipment set-up, operation, and maintenance. - 1 - User Manual Warning DANGER RISK OF FIRE OR EXPLOSION. FLAMMABLE R... lang:i-klingon score:54 filesize: 950.28 K page_count: 10 document date: 2021-06-21
	[pdf] Guide Warranty reachin refrigerationguide Reach In Refrigeration Buying Guide WebstaurantStore 10 2020 A Series Plus SS INTE RIOR CONSTRUCTION Aluminum 201 Stainless Steel C or si n e ta t 304 Stain less ee webstaurantstore documents ||| 10/2020 Reach-In Refrigeration Buying Guide 430 Stainless Steel Exterior Construction Environmental ... p To 80 lb. Each With Full-Length Handles Rear Shelf Ledge 1 or 2 Solid Door s 447AP23R, 447AP49R, 447AP23F, 447AP49F Compressor Shelf Rail 178SHELFRAIL Accommodates 1 shelf or 2 full size 12 ... lang:en score:52 filesize: 3.34 M page_count: 1 document date: 2022-06-01
	[pdf] User Manual Guide User Manual Avantco Refrigeration Manuals A Plus 44712285688 1 hp Compressor For AP 49F aplus reach in manual webstaurantstore documents ||| User Manual Commercial Refrigerators And Freezers Refrigerator models: 447AP23R, 447AP49R Freezer models: 447AP23F, 447AP49F 10/2021 Please read the manual thoroughly prior to equipment set-up, operation, and maintenance. - 1 - User Manual Warning DANGER RISK OF FIRE OR EXPLOSION. FLAMMABLE R... lang:i-klingon score:50 filesize: 697.43 K page_count: 9 document date: 2021-10-15
	[pdf] Specifications Avantco A Plus AP 23F 27 5 8 Stainless Steel Solid Door Reach In Freezer Spec Sheet Refrigeration Manuals avantco refrigeration 447ap23f specsheet 32 webstaurantstore documents specsheets ||| Item #: 447AP23F Qty: Date: Project: Approval: Avantco A Plus AP-23F 27 5/8 Stainless Steel Solid Door Reach-In Freezer Item #447AP23F Avantco Refrigeration Technical Data Features Made in North America Type 430 stainless steel exterior with a type 201 interior; self-closing, stay-open, lo... lang:en score:43 filesize: 853 K page_count: 2 document date: 2022-06-22
	[pdf] Specifications Avantco A Plus AP 49R 55 1 4 Stainless Steel Solid Door Reach In Refrigerator Spec Sheet Refrigeration Manuals avantco refrigeration 447ap49r specsheet 32 webstaurantstore documents specsheets ||| Item #: 447AP49R Qty: Date: Project: Approval: Avantco A Plus AP-49R 55 1/4 Stainless Steel Solid Door Reach-In Refrigerator Item #447AP49R Avantco Refrigeration Technical Data Features Made in North America Type 430 stainless steel exterior with a type 201 interior; self-closing, stay-ope... lang:en score:43 filesize: 1.03 M page_count: 2 document date: 2022-06-22
	[pdf] User Manual A Plus Reach In Refrigerators and Freezers Manual Only use soft cloths microfiber sponges or plastic scouring pads Avoid Contact a service technician to check refrigerant levels Door is  aplus reach in manual srsltid AfmBOoq7mssb dbltQjBChmwzuXX SbctzMi43iP8IIvOE4I4JQXPBsR webstaurantstore documents ||| User Manual 01/2025 447AP23R 447AP49F A Plus Reach-In Refrigerators Freezers Refrigerator Models: #447AP23R 27 Single Solid Door #447AP49R 55 3/8 Double Solid Door Freezer Models: #447AP23F 27 Single Solid Door #447AP49F 55 3/8 Double Solid Door Note: Read this manual in its entirety prior t... lang:en score:42 filesize: 1.59 M page_count: 12 document date: 2025-01-15
	[pdf] Specifications Avantco A Plus AP 23R 27 5 8 Stainless Steel Solid Door Reach In Refrigerator Spec Sheet prieš dienas — Made in North America this solid door refrigerator gives your establishment the performance you need and rely on for proper  Refrigeration Manuals avantco refrigeration 447ap23r specsheet 32 webstaurantstore documents specsheets ||| Item #: 447AP23R Qty: Date: Project: Approval: Avantco A Plus AP-23R 27 5/8 Stainless Steel Solid Door Reach-In Refrigerator Item #447AP23R Avantco Refrigeration Technical Data Features Made in North America Type 430 stainless steel exterior with a type 201 interior; self-closing, stay-ope... lang:en score:39 filesize: 853.33 K page_count: 2 document date: 2022-10-18
	[pdf] Specifications Avantco A Plus AP 23R 27 5 8 Stainless Steel Solid Door Reach In Refrigerator Spec Sheet Refrigeration Manuals avantco refrigeration sap 19084271 specsheet 2 webstaurantstore documents specsheets ||| Item #: 447AP23R Qty: Date: Project: Approval: Avantco A Plus AP-23R 27 5/8 Stainless Steel Solid Door Reach-In Refrigerator Item #447AP23R Avantco Refrigeration Technical Data Features Made in North America Type 430 stainless steel exterior with a type 201 interior; self-closing, stay-ope... lang:en score:35 filesize: 853.35 K page_count: 2 document date: 2022-04-27
	[pdf] Specifications Avantco A Plus AP 49R 55 1 4 Stainless Steel Solid Door Reach In Refrigerator Spec Sheet Refrigeration Manuals avantco refrigeration sap 19086259 specsheet 2 webstaurantstore documents specsheets ||| Item #: 447AP49R Qty: Date: Project: Approval: Avantco A Plus AP-49R 55 1/4 Stainless Steel Solid Door Reach-In Refrigerator Item #447AP49R Avantco Refrigeration Technical Data Features Made in North America Type 430 stainless steel exterior with a type 201 interior; self-closing, stay-ope... lang:en score:35 filesize: 1.03 M page_count: 2 document date: 2022-04-27
	[pdf] Specifications Avantco A Plus AP-49R 55 1 4" Stainless Steel Solid Door Reach-In Refrigerator Spec Sheet avantco_refrigeration_sap_19086259 cdnimg webstaurantstore documents specsheets Avantco Refrigeration PROJECT: ITEM #: 447AP49R APPROVAL: QUANTITY: DATE: Item #447AP49R Avantco A Plus AP-49R 55 1/4 Stainless Steel Solid Door Reach-In Refrigerator Item #447AP49R SPECIAL FEATURES Made in North America Type 430 stainless steel exterior with a type 201 interior; self-closing... lang:en score:28 filesize: 209.21 K page_count: 2 document date: 2021-07-22
	[pdf] Specifications California EnergyWise CEW List Update 1 29 2024 Commercial Electric Service Rebates in foodservice centerpointenergy en us Documents Midwest In Bussiness ||| Table of Contents Indiana CEW Qualifying Foodservice Equipment Equipment must meet program specifica ... Model Number ACF332D* ALF62* FS24L* FS407*/FS408* MBF8504 178AU60FHC 178AWT60FHC 178Z1FHC 178Z2FHC 447AP23F 447AP49F CFD-1FF MCCF5F0W MCCF7F0W FB35HC-1*S********* FB44HC-1***** FB49HC-1***** HBF35HC-... lang:en score:11 filesize: 740.53 K page_count: 123 document date: 2024-07-01
	[pdf] 2024 Q2 PSE CFS QPLs v2 xlsx Shayna Choulet REFRIGERATORS commercial only CSD 2DR BAL ES 41 6 Solid Door $1 000 Centaur Plus TSI 42 5 HC N A CUR 28 48   Refrigerators pse media REBATES Commercial Foodservice Equipment ashx sc lang en rev 1 modified 00010101000000 hash 3B0B4E8A430E732D74987DDAC4000F6D ||| QUALIFIED PRODUCTS LIST: REFRIGERATORS commercial only Updated June 2024 Manufacturer AHT AHT AH ... 08 178A49RGHC 178SSUC36RHC 178SSWT36RHC 178UBB378* 178UDD378* 178Z1RGHC 178Z1RHC 178Z2RGHC 178Z2RHC 447AP23R 447AP49R CFD-1RR CFD-2RR 178Z1R2A 178Z1RGHC 178Z2R4K 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 1... lang:i-klingon score:9 filesize: 886.93 K page_count: 70 document date: 2024-06-27